Carrier 59MN7A Instruction Manual download pdf (Page 52)

HORIZONTAL LEFT -

RIGHT VENT CONFIGURATION*

*Requires Accessory Internal Vent Kit

See Product Data for Current Kit Number

HORIZONTAL LEFT -

VERTICAL VENT CONFIGURATION

HORIZONTAL LEFT -

LEFT VENT CONFIGURATION

Attach vent pipe adapter with gasket to furnace casing.

Align notches in rubber coupling over standoffs on adapter. Slide clamps over the coupling.

Slide vent pipe through adapter and coupling into vent elbow.

Insert vent pipe into vent elbow.

Torque all clamps 15 lb.-in.

Attach combustion air pipe to adapter with silicone. Pilot drill a 1/8-in.

hole in adapter and secure with a #7 x 1/2-in sheet metal screw.

Attach combustion air pipe adapter with gasket to furnace.

A11340

Fig. 40 -- Horizontal Left

(Appearance May Vary)

59MN7A

1 2 ... 47 48 49 50 51 52 53 54 55 56 57 ... 89 90

Series 200 1
IMPORTANT 2
SAFETY CONSIDERATIONS 3
INTRODUCTION 4
CODES AND STANDARDS 4
ELECTROSTATIC DISCHARGE (ESD) 4
PRECAUTIONS PROCEDURE 4
ACCESSORIES 5
LOCATION 5
* Recommended 6
Fig. 1 -- Dimensional Drawing 7
18-IN. (457.2 mm) 8
MINIMUM TO BURNERS 8
AIR FOR COMBUSTION AND 9
VENTILATION 9
CONDENSATE TRAP 11
(Appearance May Vary) 12
CONDENSATE DRAIN CONNECTION 16
Horizontal Orientation 17
INSTALLATION 19
Horizontal Installation 20
Filter Arrangement 20
Fig. 17 -- Media Filter 22
UPFLOW DOWNFLOW HORIZONTAL 24
HORIZONTAL TOP 25
RETURN NOT 25
PERMITTED FOR 25
ANY MODEL 25
COMBUSTION - AIR PIPE 26
(SEE VENTING SECTION) 26
AIR DUCTS 27
Table7–Cooling 28
With Filter) 28
Table 7 -- Cooling 29
With Filter) (Continued) 29
GAS PIPING 31
115--V Wiring 32
J--Box Installation 33
24--V Wiring 33
Alternate Power Supplies 34
12 and 16 38
Materials 41
Venting Systems 41
Locating the Vent Termination 41
Guidelines 42
Configure the Furnace 42
Pipe Adapter 43
Vent Coupling and Adapter 49
Downflow Vertical 51
HORIZONTAL LEFT 52
RIGHT VENT CONFIGURATION* 52
Fig. 41 -- Horizontal Right 53
TOP PLATE ATTACHMENT 54
COMBUSTION AIR PIPE 54
(ATTIC OR CRAWLSPACE ONLY) 54
Abandoned masonry 57
(per code) 57
OVERHANG 58
12 in. (304.8mm) MIN. Ground 58
Level OR Snow Level 58
Select Setup Switch Positions 60
Purge Gas Lines 61
Adjustments 61
Adjust Temperature Rise 62
Check Safety Controls 64
Checklist 64
338307-201 Rev. F 65
A11575 AMV 67
MODULATING FURNACE 69
U.S.A. Only 72
SERVICE AND MAINTENANCE 73
PROCEDURES 73
Component Self--Test 74
Care and Maintenance 74
Servicing Hot Surface Igniter 77
WINTERIZATION 78
Burner Flame 79
Manifold 79
Fig. 60 -- Blower Assembly 80
Fig. 61 -- Burner Assembly 81
Troubleshootin 82
SEQUENCE OF OPERATION 85
(Adaptive Mode) 86
Maximum Heating 87
Cooling Mode 87
Catalog No:59MN7A---04SI 90

Comments to this Manuals

No comments

Carrier 59MN7A Instruction Manual Page 52

Comments to this Manuals

Related products and manuals for Water heaters & boilers Carrier 59MN7A